Flaps (SWIRL) OFF

They are controlled by the ECU (engine control unit) or engine computer in the vehicle which when the engine is idling keeps the dampers closed and thus increases the turbulence in the intake manifold and vacuum and thus 

allows better atomization and combustion of the mixture thus reducing emissions. Also, with the optimal position of the mudguards, the engine gets the set torque when accelerating from low revs and the turbo hole is less pronounced. When the engine reaches its maximum torque the dampers are usually open and then the engine can develop all the declared power. 

Flaps problems are quite common due to poor fuel quality (insufficient purification) and continuous refuelling, soot build-up and mechanical blocking are common, but it often happens that the flaps themselves fall into the engine cylinder resulting in severe mechanical damage to the engine and cost repair. 

▶️The most common symptoms of FLAPS problems are: 

✅️Restless engine idling 

✅️Bigger turbo hole 

✅️Less engine power 

✅️Limiting engine power (safe mode, limp mode) 

✅️Appearance of MIL lamp (check engine lamp) 

✅️Clicking the sound coming from them 

✅️Cessation of DPF regeneration and clogging of the DPF 

✅️Problems with EGR valve and MAF sensor 

✅️Valves falling into the engine and mechanical destruction of the engine 

▶️There are several ways to solve the FLAPS problem: 

✅️ removal and cleaning - if the problem is in the mechanical clogging it can help but if the problem is of an electronic nature in the damper electronics, cleaning will not help 

✅️used flaps - the rule applies as for any used item, it can last a long time and may break down again the next day 

✅️new flaps - this will certainly solve the problem of 

the next 20,000 km approximately how much they need to be re-heated and stuck after replacement, but the problem is also the price because it is not a cheap repair.

✅️deregistering FLAPS from the engine computer 

and possibly putting plugs in their place - a permanent solution to all the problems that FLAPS can cause With the correct and quality FLAPS off, the engine will work completely correctly without any lamps, errors and limp modes. Also, the DPF will continue to perform regeneration at the prescribed intervals. 

▶️During the technical inspection, it will not be possible to notice the FLAPS off and the vehicle will pass all ECO tests. 

▶️ Mechanical removal of flaps with FLAPS off prevents the scenario in which flaps can fall into the engine and destroy it. 

▶️In practice, the turbo hole created by removing FLAPS is negligible and 

imperceptible if the whole procedure is done with quality.