Toyota Tacoma 2005-2009 - 30,000 - 60,000 - 90,000 - 120,000 Mile Maintenance Items

The following information is based on information found at http://smg.toyotapartsandservice.com/

 Replace engine oil and oil filter 1
 Rotate tires
 Replace limited-slip differential oil, if equipped (4WD and PreRunner)
 Replace spark plugs 6
 Re-torque propeller shaft bolt
 Replace engine air filter
 Replace cabin air filter (if equipped)
Inspect the following:
  Automatic transmission fluid 
  Ball joints and dust covers 
  Brake lines and hoses 
  Brake linings/drums and brake pads/discs 7 
  Drive shaft boots (4WD) 
  Engine coolant 8 
  Exhaust pipes and mountings 
  Front differential oil (4WD) 
  Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses 
  Fuel tank cap gasket 
  Radiator, condenser and/or intercooler 
  Rear differential oil 
  Steering gear box 
  Steering linkage and boots 
  Transfer case oil (4WD) 
 

Additional Maintenance Items for Special Operating Conditions:

Driving While Towing
 Replace front differential oil (4WD)
 Replace rear differential oil, including limited-slip
 Replace transfer case oil (4WD)
 Tighten nuts and bolts on chassis
Driving in Desert or On Dirt Roads
 Tighten nuts and bolts on chassis
 
Applicable Footnotes:
1) Reset the oil replacement reminder (“MAINT REQD”) light after replacing engine oil, if vehicle is equipped with this light.
6) Applies to Tacoma with 1GR-FE. Required under the terms of the Emission Control Warranty.
7) Inspect thickness measurement and disc runout.
8) See Maintenance Definitions (Engine Coolant) for details.


ALL INFORMATION HERE IS FOR INFORMATIONAL PURPOSES ONLY.  YOUR VEHICLE MAY BE DIFFERENT AND REQUIRE DIFFERENT PARTS AND PROCEDURES.  PLEASE BE CAREFUL WHEN WORKING ON OR UNDER YOUR VEHICLE.
Comments